Storing Large Round Bales

Storing Large Round Bales

As hay is being cut and put in large round bales, it is always important to reduce hay storage losses. University of Tennessee animal scientists conducted a trial to compare different methods of storing large round bales of grass hay. The hay was cut and baled in June in Moore County, Tennessee. The bales were weighed at the time of harvest and storage. Then they were weighed again the following January at the time of winter feeding. The following table lists the type of storage and the resulting percentage hay loss.

Table 1. Losses of hay stored using six methods of storage  (Source: Clyde Lane, University of Tennessee Department of Animal Science)

Average spring, summer, and fall rainfall in Tennessee will generally be greater than that experienced in much of Oklahoma.  However the rankings in storage loss between the storage methods will be present in Oklahoma as well.

An Oklahoma State University fact sheet by Ray Huhnke summarizes differences in storage loss that can be expected in an Oklahoma ranch setting.  Source:  Oklahoma Cooperative Extension Fact Sheet BAE-1716 “Round Bale Hay Storage”.

Table 2. Percentage (%)  dry matter loss of round hay bales. 

Obviously, it would be ideal to store the hay inside, but that will not often be practical. The next best option is when the hay is stored on something that gets the hay off of the ground under a rain shedding cover.  

Other important storage concepts can be used as the hay is being harvested this spring and summer.

The storage site is an important consideration in reducing bale losses. Select a site that is not shaded and is open to breezes to enhance drying conditions. The site should also be well-drained to minimize moisture absorption into the underside of the bales. As much as 12 inches of the bottom of a bale can be lost through moisture absorption resulting from the wicking action.. Ground contact can account for over half of the total dry matter losses. Where practical, keep bales off the ground using low cost, surplus materials such as discarded pallets, racks, fence posts, railroad ties, and used tires. Another alternative is to use a layer of crushed rock about six inches deep to ensure good drainage within and around the storage site.

Bales should be stored in rows, buffed end-to-end, and oriented in a north/south direction. The combination of the north/south orientation and at least three feet between rows will provide for good sunlight penetration and air flow, which will allow the area to dry faster after a rain. Vegetation between rows should be mowed. Research has shown that orientation is a minor consideration if the bales are used before early spring because the losses are relatively small until that time. If stored into the summer, bales oriented in an east-west direction can experience severe deterioration on the north-facing surface.

The source of these and other ideas about hay storage can be found in Ray Huhnke’s Oklahoma Cooperative Extension Fact Sheet “Round Bale Storage” BAE-1716.

 

Latest News

Biden Administration Restores Wildlife Protections
Biden Administration Restores Wildlife Protections

The U.S. Fish and Wildlife Service plans to reinstate rules protecting endangered plants and animals, action that would reverse changes made during the Trump Administration that weakened the Endangered Species Act.

Across Breed EPD Adjustment Factors
Across Breed EPD Adjustment Factors

EPDs from multiple breeds can be compared by adding/subtracting the appropriate adjustment factors to the EPDs resulting from the most recent genetic evaluations for each of 18 breeds.

APHIS Now Thinks Wild Birds Are to Blame for Highly Pathogenic Avian Influenza's Arrival on Four U.S. Dairies
APHIS Now Thinks Wild Birds Are to Blame for Highly Pathogenic Avian Influenza's Arrival on Four U.S. Dairies

The livestock industry continues to grapple with the first confirmed cases of HPAI in cattle, while federal and state agencies continue to assure consumers there's no concern about the safety of the U.S. milk supply.

Skills Survey Reveals U.S. Agriculture & Food Industry Workforce Needs and Gaps
Skills Survey Reveals U.S. Agriculture & Food Industry Workforce Needs and Gaps

U.S. employers report challenges in finding suitable job candidates with work-ready skills to fill open roles in ag. The AgCareers.com U.S. Skills Survey offers insights, data and trends to address skill development.

USDA Authorizes CRP Graze and Hay Donations to Wildfire Victims
USDA Authorizes CRP Graze and Hay Donations to Wildfire Victims

Conservation Reserve Program (CRP) participants can donate emergency grazing authority to ranchers in Nebraska, Oklahoma and Texas impacted by recent wildfires.

New Guide Helps Producers Maximize Values of Cull Cows
New Guide Helps Producers Maximize Values of Cull Cows

A new resource developed by the National Cattlemen’s Beef Association and CattleFax helps cattle producers maximize profitability from their culling decisions.